Vol. 22 No. 1 (2019) Cover Image
Vol. 22 No. 1 (2019)

Published: March 31, 2019

Pages: 44-54

Articles

Enhancement of Heat Transfer using Aluminum Oxide Nanofluid on Smooth and Finned Surfaces with COMSOL Multiphysics Simulation in Turbulent Flow

Abstract

Both surface extension and nanofluid methods were used to enhance the heat transfer in a double pipe heat exchanger under turbulent flow conditions. Aluminum oxide nanoparticles were used with different concentrations(0.6-3 g/l)in hot water to increase the heat transfer rate on smooth tube and circular fins tube for a range of Reynolds number4240-19790. The simulation was also performed to predict the heat transfer coefficient and temperature profile for selected conditions in which COMSOL Multiphysics is used. The experimental results revealed that the heat transfer enhancement by both circular fin and nanofluid exhibited an increasing trend with Reynolds number and nanofluid concentration. The conjoint effect of Al2O3 of 3 g/l concentration and circular fin provided largest heat transfer enhancement of 53% for the highest Re investigated. Simulation results showed reasonable agreement with the experimental values of heat transfer coefficient. The simulation showed that the presence of nanofluid on finned surface influenced the temperature profile indicating the increased heat transfer rate.

References

  1. N. Y. Kim, Y. P. Lee, S. Y. Youn, J. S. Jurng, "A study on the pressure loss, heat transfer enhancement and fouling control in a vertical particulate flow"., KSME Journal, 1996,10 (4), 450.
  2. N. H. Kim, Y. P. Lee, " Hydrodynamic and heat transfer characteristics of glass bead-water flow in a vertical tube "., Desalination, 2001, 33, 233.
  3. H. K. Kang, B. C. Lee, S. W. Ahn, J. W. Choi, S. H. An, "Numerical and experimental analyses of anti-fouling and heat transfer in the heat exchanger with circulating fluidized bed, The Canadian Journal of Chemical Engineering"., The Canadian Journal of Chemical Engineering,2011, 240.
  4. W. Duangthongsuk, S. Wongwises,"Heat transfer enhancement and pressure drop characteristics of TiO2–water nanofluid in a double-tube counter flow heat exchanger ", International Journal of Heat and Mass Transfer,2009, 52, 2059.
  5. A. Zamzamian, S. N. Oskouie, A. Doosthoseini, A. A. Joneidi, M. Pazouki, " Experimental investigation of forced convective heat transfer coefficient in nanofluids of Al2O3/EG and CuO/EG in a double pipe and plate heat exchangers under turbulent flow "., Experimental Thermal and Fluid Science,2011, 35 (3) 495.
  6. M. M. Sarafraz, V. Nikkhah, F. Hormozi, "Low-frequency vibration for fouling mitigation and intensification of thermal performance of a plate heat exchanger working with CuO/water nanofluid, Applied Thermal Engineering"., Applied Thermal Engineering.2017, 121, 388.
  7. H. S. Majdi, B. O. Hasan, Hussein A. Alabdly, M. M. Hathal, " Oil fouling in double pipe heat exchanger under liquid-liquid dispersion and the influence of CuO nanofluid, Unpublished Results, Department of Chemical Engineering, Al-Nahrain University, Iraq, 2019.
  8. J. Albadr, A. S. Tayal, M. Alasadi, Heat transfer through heat exchanger using Al2O3nanofluid at different concentrations., Case Studies in Thermal Engineering, 2013,1, 38.
  9. M. S. Baba, A. V. Sita, R. Rajuc, M.B. Raod, Heat transfer enhancement and pressure drop of Fe3O4 -water nanofluid in a double tube heat exchanger with internal longitudinal fins, Case Studies in Thermal Engineering, 2018,12, 600.
  10. A. K. Tiwari, P. Ghosh, J. Sarkar," Heat transfer and pressure drop characteristics of CeO2/water nanofluid in plate heat exchanger, Applied Thermal Engineering", Applied Thermal Engineering,2013, 57, 24.
  11. A. N. Khalifa , M. A. Banwan," Effect of Volume Fraction of γ‐Al2O3 Nano-fluid on Heat Transfer Enhancement in a Concentric Tube Heat Exchanger, Heat Transfer Engineering, 2015, 36 (6), 1387-1396.
  12. A. M. Hussein, Bakar, R. A., Kadirgama, K., 2014., “Study of forced convection nanofluid heat transfer in the automotive cooling system”, Case Studies in Thermal Engineering., Elsevier., 2., 50–61.
  13. A. A. Kramallah, N. S. Mahmoud, A. M. AL-Tajer, 2018, "Numerical Study of Heat Transfer and Flow of Nanofluid Using Multi-Phase Mixture Model through Elliptical Tubes"., Journal of University of Babylon for Engineering Sciences, Vol. (26), No. (6).
  14. B. Mehdi, R. Reza, Y. Ali, K. Erfan, M. Ramin, A. Mohammad, " Recent research contributions concerning use of nanofluids in heat exchangers: A critical review ".,Applied Thermal Engineering, 2018,133 (25), 137.
  15. B. O. Hasan, E. A. Jwair, R. A. Craig," The effect of heat transfer enhancement on the crystallization fouling in a double pipe heat exchanger", Experimental Thermal and Fluid Science,2017, 86, 272.
  16. S. K. Kumar, K. Vasudev, M. Krishna," Numerical study of heat transfer in a finned double pipe heat exchanger"., World Journal of Modelling and Simulation,2015, 11(1), 43.
  17. I. M. Ali, M. A. Mussa, M. M. Mustafa," Experimental Investigation of Forced Convection Heat Transfer in Open Cell Copper Fins"., Al-Nahrain Journal for Engineering Sciences (NJES),2017, 20 (1), 272.
  18. B. K. Mahato, F. R. Stewrd, and L. W. Shimlit," Steel pipe corrosion under flow conditions—II"., Corros. Sci.,1968, 8, 773–783.
  19. J. P. Holman, Heat transfer, 10th Edition, McGraw Hill, Boston, 2010.
  20. Q. J. Slaiman, B. O. Hasan, "Study on corrosion rate of carbon steel pipe under turbulent flow conditions ", The Canadian Journal of Chemical Engineering,2010, 88 (6), 1114-1120.
  21. B. O. Hasan, G. J. Nathan, P. J. Ashman, R. A. Craig, R. M. Kelso, " The use of turbulence generators to mitigate crystallization fouling under cross flow conditions, Desalination", Desalination, 2012, 288 (1) 108.
  22. O. A. Mohsen, Experimental investigation and simulation of convective heat transfer through double pipe heat exchanger with different extended surfaces, MSC thesis, Chemical Engineering Department, Al-Nahrain University, Iraq 2018.
  23. Y. Xuan, Q. Li, Transfer enhancement of nanofluids", International Journal of Heat and Fluid Flow, 2000, 21, 58.
  24. M. M. Hathal, M.sc thesis, "Experimental study on the effect of turbulent dispersion on heat exchanger performance", Department of Chemical Engineering, Al-Nahrain University, Iraq, 2018.
  25. P. V. Shaw, T. J. Hanratty, Fluctuations in the local rate of turbulent mass transfer to a pipe wall", A. I. Ch. E. J., 1964, 13, 689.
  26. T. Mizushina, F. Ogino, Eddy Viscosity and universal velocity profile in turbulent flow in a straight pipe, J. Chem. Eng. of Japan,1970, 3, 166.
  27. D. B. De Graaff, D.R. Webster, J. K. Eaton, The effect of Reynolds number on boundary layer turbulence,"., Experimental Thermal and Fluid Science,1998, 18(4), 341.
  28. Q. J. Slaiman, M. M. Abu-Khader, B. O. Hasan," Prediction of heat transfer coefficient based on eddy diffusivity concept "., Trans. IChemE, Part A, Chem. Eng. Res. Design, 2007, 85 (A4), 455.
  29. B. O. Hasan, Heat transfer analysis in thermal entrance region under turbulent flow conditions, Asia pacific J. Chemical Eng., 2013, 8 (4) 578-592.
  30. C. S. Jwo, L. Y. Jeng, T. P. Teng, C. C. Chen, "Performance of Overall Heat Transfer in Multi-Channel Heat Exchanger by Alumina Nanofluid ", Journal of Alloys and Compounds, 2010, 504, 385.